22 amazing years with the Peregrine.
Yanmar 3GM30F - 2156.6 hours - 01/01/2023
January
- Oil change with electric oil extractor/filter (TRICKS)
- Use clear hose
- Position drill and pump low and through the removed staircase opening
- Blow on clear hose until you locate oil in sump
- Attach clear hose to pump
- Green hose to disposal container
- Run drill at full speed clockwise
- Measure extracted oil to ensure it's close to 2.7L DElo 400 SAE Viscosity 30W
- Replace oil filter
- Refill oil but don't overfill!
- Racor filter (TRICKS)
- Shut off inlet valve feeding deisel to Racor
- Remove T-handle and filter
- Replace 2 O-rings and install new filter
- Top off Racor by opening inlet valve slightly to allow deisel to fill to top
- Reinstall T-handle
- Installed new Gusher manual bilge pump
- Raw water strainer flushed
- Corroseal on motor mounts
- All hose clamps tightened
February
- Wired black water tank sensor
March
- New starting batteries (house batteries new 5/20)
- Corroplex hatchway
April
- New Alpicool 23 Quart refridgerator
- New mirror on head door
May
- Hardwired forward battery charger
- Installed lighter plug receptical
- Installed red LED lights at nav station
June
- Haul out
- Remove dodger, hardware, etc.
- Deck paint
- Finish gelcoat on non-skid, deck, toe rails
- Bottom paint
- Boot stripe
- Marinetex chips on hull rail/topsides
- Inspect thru-hulls
- Kill rust/Corroseal under mast
August
- BlueSea AC Main 30A 120v circuit breaker
- Rule Bilge Pump Switch
- Sand Marinetex on topsides
- Repair paint chips in cockpit
To do list:
- Pull mast
- Mast paint
- Replace shrouds
- Replace spreader boots
- Remove vibration dampner
- Mast conduit
- LED Steamer light
- Gearbox seal
- Motor mounts (currently at 6mm)
- Anchor light/run wiring up pole
- Replace pumpout sanitation hose - 9' of 1" ID
- Replace vent sanitation hose - x' of 5/8" ID with new 90deg elbow
- Head inspection port
- Engine compartment drain
- Seal forward toe rail drain holes
- Add 1/4" aluminum backing plates to toe rails
- Diesel Heater
- Shrouds
- Mast wiring conduit
- Optimize solar panels
2018 (and earlier) maintenance »
