This beauty was installed in October 2001 replacing the Palmer P60 gas engine. I paired the transmission with a 3-blade 13in fixed propeller. It will run all day at 2800rpm burning only 0.6 gal per hr. With a 27 gallon fuel tank, that's approximately 45hrs of run time between fuel ups. It has definitely made cruising a pleasure.
Type: Vertical, fresh water cooled, 4-cycle diesel engine
Model: 3GM30(F)
Cylinders: 3
Continuous output rating: 17.7kW (24PS)/3400min-1
Maximum output: 19.9kW (27PS)/3600min-1
Engine oil capacity: 2.7L DElo 400 SAE Viscosity 30W
Clutch oil: 0.3L SAE Viscosity #30
Fuel filter: Racor 500FGSS (new 2016)
Yammer built the 3GM30 from 1983-2005.
Maintenance/Upgrade Log
2018 (1741hrs)
- Rigging inspection
- Valve Adjustment
- Raw water pump
- Rear main seal/bearing
- Crankshaft rear seal
- Engine alignment
- Replace fuel lines on engine and engine fuel filter housing
- Drained coolant and changed out coolant hoses and clamps, refilled system with fresh Yanmar coolant
- Changed lube oil and filter
- Changed air filter
- Changed transmission oil
- Fuel lift pump gasket
- Thermostat
- Adjusted throttle cable tension
- Fuel Lift Pump
- Oil/Filter
- Racor 30micron primary and secondary filter
- Galley Spray Faucet
- Galley Water Filter
- Head Faucet
- LED Cabin lights
- Zinc on shaft (May)
- Fuel Lift Pump
- Dodger/Bimini Connector Panel
- 3 Small Forward Portside Portlights
- Traveller blocks and lead lines
2017
- Oil/Filter
- Racor 10micron filter
- Autopilot
- Windless
- Solar
- Bimini
- Zinc on shaft
2016
- Oil/Filter
- Racor 10micron filter
- Dodger
2015
- Oil/Filter
- Racor 10micron filter
- Racor Assembly
2014
- Oil/Filter
- Racor 10micron filter
- Exhaust Elbow
2013
- Oil/Filter
- Racor 10micron filter
- Raw Water Pump/impeller
2012
- Oil/Filter
- Racor 10micron filter
2011
- Oil/Filter
- Racor 10micron filter
- Timing Gear Case Seal
2010
- Oil/Filter
- Racor 10micron filter
- Raw Water Impeller
2009
- Oil/Filter
- Racor 10micron filter
- Raw Water Impeller
2005
- Raw Water Impeller
2004
- xxx
2003
- xxx
2002
- Valve Adjustment
2001
- Yanmar 3GM30F
No comments:
Post a Comment